Product ID:438 TEFLON COATING (AEROSOL)
MSDS Date:07/22/1993
FSC:8030
NIIN:00N088356
MSDS Number: CHLYX

A W CHESTERTON CO

225 FALLON RD
STONEHAM, MA 02180-2999
US

Emergency Phone: 800-535-5053

Info Phone: 617-438-7000

Cage: 71431

CHESTERTON A W CO

STONEHAM, MA 02180-9101 US

Telephone: 781-438-7000/800-535-5053

Cage: 71431

54.

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 1-5%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

70.

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 10-20%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM; 300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

182.

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 50-60%

OSHA PEL 1000 PPM

ACGIH TLV: 750 PPM; 1000 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PROPANE

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 5-15%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT

ISOBUTANE

CAS: 75-28-5

RTECS: TZ4300000

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

N-BUTANE

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 1-5%

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM

OF THE PRODS, BUT AIR CONC SHOULD BE MINIMAL.

RTECS: 9999999ZZ

REASON. IF INGESTED IN LARGE QUANTITIES, THE PRODUCT

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: DIRECT EYE CONTACT CAUSES EYE
IRRIT. INHAL OF VAP CONCS IN EXCESS OF PEL/TLV MAY RESULT IN
DIZZINESS, HEADACHE, OTHER CNS EFTS & MAY ALSO IRRITATE EYES & RESP
TRACT. CHRONIC: TOLUENE APPEARS ON THE NAVY LIST OF OCCUP CHEM
REPRO HAZS. SEEK CONSULTATION FROM APPROP HEALTH PROFESSIONALS
CONCERNING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: LATEST HAZ LIST INFO & SAFE HNDLG &
EXPOS INFO . PRLNGD/RPTD SKIN CONTACT MAY CAUSE SKIN IRRIT, POSS
ALLERGIC RXNS & MAY DEFAT SKIN. IT CAN BE ABSORBED THRU INTACT SKIN
IN HARMFUL AMTS . AS PER 29 CFR 1910.1200 (HAZ COMMUNICATIONS),
THERE ARE NO CARCINS IN THIS PROD AS LISTED IN NTP, IARC OR OSHA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, ADMINISTER
ARTIFICIAL RESPIRATION. CONTACT MD. EYE/SKIN CONTACT: WASH SKIN
WITH SOAP AND WATER. FLUSH EYES FOR AT LEAST 15 MINUTES WITH LARGE
AMOUNTS OF WATER. CONSULT MD IF IRRITATION PERSISTS. INGESTION: IF
CONSCIOUS, INDUCE VOMITING. CONTACT MD IMMEDIATELY.

Flash Point:-0F,-18C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:PRESSURIZED CONTAINERS WHEN HEATED ARE A
POTENTIAL EXPLOSIVE HAZARD.

Spill Release Procedures:EVACUATE AREA. PROVIDE ADEQUATE VENT. CONTAIN
SPILL TO SMALL AREA. FLUSH AWAY FROM IGNITION SOURCES W/WATER. PICK
UP W/ABSORB MATL (EG SAWDUST, SAND, CLAY, ETC) & TRANSFER TO
SUITABLE CNTNR FOR DISPOS AL. KEEP OUT OF SEWER, STREAM &
WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE IN DIRECT SUNLIGHT OR
ABOVE 49C(120F). AVOID CONTAMINATION OF TOBACCO PRODUCTS.
Other Precautions:VAPS ARE HVR/AIR & WILL COLLECT IN LOW AREAS. DO NOT
SMOKE WHILE USING PROD. TEFLON PROTECTS & LUBRICATS SMOOTH
NONPOROUS SURFS. SOLVS, USED AS DILUENTS, PRESENT INHAL HAZ TO
USERS OF THIS PROD. IN AD DN, PRLNGD/EXCESSIVE SKIN CNTCT (SUPDAT)

Respiratory Protection:NOT NORMALLY NEEDED. IF PEL/TLV IS EXCEEDED, USE
NIOSH APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:NO SPECIAL REQUIREMENTS. IF PEL/TLV IS EXCEEDED, PROVIDE
ADEQUATE VENTILATION.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
IMPERVIOUS CLOTHING AS NECESSARY TO PREVENT SKIN CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PRECS: COULD DEFAT SKIN & CAUSE DERM. TEFLON, WHEN HEATED IN
EXCESS OF 260C(500F), GIVES OFF VAPS WHICH MAY CAUSE TEMPORARY
FLU-LIKE SYMPS IF INHALED. THIS THERMAL DECOMP LEADS TO FORM OF
OXIDIZ ED PRODS CONTAINING CARBON, FLUORINE & OXYG. ACGIH STATES NO
TLV IS RECOM PENDING DETERMINATION OF TOXICITY (ING 7)

Boiling Pt:B.P. Text:>133F,>56C
Vapor Pres:SEE INGS
Vapor Density:>1
Spec Gravity:0.75
Evaporation Rate & Reference:<1 (ETHER=1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:97.9

Stability Indicator/Materials to Avoid:YES
ACIDS AND BASES AND STRONG OXIDIZERS LIKE LIQUID CHLORINE AND
CONCENTRATED OXYGEN.
Stability Condition to Avoid:OPEN FLAMES AND RED HOT SURFACES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER TOXIC FUMES.

Waste Disposal Methods:INCINERATE ABSORBED MATERIAL. DO NOT INCINERATE
SEALED CONTAINERS. LANDFILL SEALED CONTAINERS IN AN APPROVED AREA.
CHECK LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.